Codes P3137/P0642/P2004/P0299

[jmjm15213]

To start, car is a 2006 mkV GTI, 2.0T FSI Motor. Purchased a year ago at 36k miles, currently sits at 50k. Purchased with a Stage 3 APR kit installed. MIL lit on 6/21 immediately following a gas fill up, so I figured it was me failing to tighten the gas cap. Been through 6 cycles of off and on, still have a lit MIL. Seems to be peaking at 17-19 psi of boost instead of the normal 22ish. I found results related to updating software, if I read this correctly I sit with version 0030.

Also noticed the other faults. I think the door closing mechanism is starting to seize on the drivers side, car doesn't recognize an open door half the time now. The radio codes probably deal with an aftermarket I installed. Not sure about the Central Conv code, does this deal with the A/C? Car currently does not have working A/C, I assumed it was the compressor.

Any additional information or insight on the codes would be appreciated.

Monday,25,June,2012,18:46:16:48040
VCDS Version: Release 11.11.3
Data version: 20120401



--------------------------------------------------------------------------------
--------------------------------------------------------------------------------


Chassis Type: 1K0
Scan: 01 03 08 09 0F 15 16 17 19 1C 25 42 44 46 52 55 56

VIN: WVWEV71K16W196956 Mileage: 81250km/50486miles

00-Steering Angle Sensor -- Status: OK 0000
01-Engine -- Status: Malfunction 0010
03-ABS Brakes -- Status: OK 0000
08-Auto HVAC -- Status: OK 0000
09-Cent. Elect. -- Status: OK 0000
0F-Digital Radio -- Status: Malfunction 0010
15-Airbags -- Status: Malfunction 0010
16-Steering wheel -- Status: OK 0000
17-Instruments -- Status: OK 0000
19-CAN Gateway -- Status: Malfunction 0010
1C-Position Sensing -- Status: OK 0000
25-Immobilizer -- Status: OK 0000
42-Door Elect, Driver -- Status: Malfunction 0010
44-Steering Assist -- Status: OK 0000
46-Central Conv. -- Status: Malfunction 0010
52-Door Elect, Pass. -- Status: OK 0000
55-Xenon Range -- Status: OK 0000
56-Radio -- Status: Cannot be reached 1100

-------------------------------------------------------------------------------
Address 01: Engine Labels: 06F-907-115-AXX.lbl
Part No SW: 1K0 907 115 B HW: 1K0 907 115 B
Component: 2.0l R4/4V TFSI 0030
Revision: --H14--- Serial number: VWZ7Z0F3964525
Coding: 0403010A18070160
Shop #: WSC 06527 444 54185
VCID: 254BD262ECFA271

4 Faults Found:
012599 - Intake Manifold Runner Control
P3137 - 001 - Basic Setting not Completed - Intermittent
Freeze Frame:
Fault Status: 00100001
Fault Priority: 0
Fault Frequency: 1
Mileage: 80481 km
Time Indication: 0

Freeze Frame:
RPM: 0 /min
Load: 100.0 %
Speed: 0.0 km/h
Temperature: 54.0°C
Temperature: 52.0°C
Absolute Pres.: 990.0 mbar
Voltage: 8.890 V

001602 - Sensor Reference Voltage A: Circuit
P0642 - 002 - Low - Intermittent
Freeze Frame:
Fault Status: 00100010
Fault Priority: 0
Fault Frequency: 1
Mileage: 80481 km
Time Indication: 0

Freeze Frame:
RPM: 0 /min
Load: 100.0 %
Speed: 0.0 km/h
Temperature: 54.0°C
Temperature: 52.0°C
Absolute Pres.: 990.0 mbar
Voltage: 8.636 V

008196 - Intake Manifold Flap; Bank 1
P2004 - 008 - Stuck Open - Intermittent
Freeze Frame:
Fault Status: 00101000
Fault Priority: 0
Fault Frequency: 1
Mileage: 80491 km
Time Indication: 0
Date: 2000.00.00
Time: 19:57:19

Freeze Frame:
RPM: 0 /min
Load: 0.0 %
Speed: 0.0 km/h
Temperature: 87.0°C
Temperature: 45.0°C
Absolute Pres.: 980.0 mbar
Voltage: 13.081 V

000665 - Boost Pressure Regulation
P0299 - 002 - Control Range Not Reached - Intermittent - MIL ON
Freeze Frame:
Fault Status: 10100010
Fault Priority: 0
Fault Frequency: 1
Mileage: 80630 km
Time Indication: 0
Date: 2000.00.00
Time: 21:17:05

Freeze Frame:
RPM: 3068 /min
Load: 64.3 %
Speed: 126.0 km/h
Temperature: 84.0°C
Temperature: 35.0°C
Absolute Pres.: 990.0 mbar
Voltage: 14.097 V

Readiness: 0000 0001

-------------------------------------------------------------------------------
Address 03: ABS Brakes Labels: 1K0-907-379-MK60-F.lbl
Part No SW: 1K0 907 379 AA HW: 1K0 907 379 AA
Component: ESP FRONT MK60 0102
Revision: 00H13001
Coding: 0021122
Shop #: WSC 01279 785 00200
VCID: 71E3F63268B23B1

No fault code found.

-------------------------------------------------------------------------------
Address 08: Auto HVAC Labels: 1K0-820-047.lbl
Part No: 1K0 820 047 EB
Component: Climatic PQ35 090 0505
Shop #: WSC 00000 000 00000
VCID: 68D59B565B68FA9

No fault code found.

-------------------------------------------------------------------------------
Address 09: Cent. Elect. Labels: 3C0-937-049-23-H.lbl
Part No SW: 3C0 937 049 Q HW: 3C0 937 049 Q
Component: Bordnetz-SG H46 1501
Revision: 00H46000 Serial number: 00000005469053
Coding: 078F0F214004150000140000001400000008770B5C0000
Shop #: WSC 06527 444 84760
VCID: 3777082A4656A51

Subsystem 1 - Part No: 1K1 955 119 C Labels: 1KX-955-119.CLB
Component: Wischer VW350 013 0402
Coding: 00063445
Shop #: WSC 06527

No fault code found.

-------------------------------------------------------------------------------
Address 0F: Digital Radio Labels: 8E0-035-593-XM.lbl
Part No SW: 8E0 035 593 E HW: 8E0 035 593 E
Component: SDAR XM H03 0080
Revision: 00000000 Serial number: AUZ4Z7F7047952
Shop #: WSC 00000 000 00000
VCID: 2B5F245A8A1E111

3 Faults Found:
00003 - Control Module
014 - Defective
Freeze Frame:
Fault Status: 01101110
Fault Priority: 5
Fault Frequency: 1
Reset counter: 129
Mileage: 3169 km
Time Indication: 0
Date: 2000.00.00
Time: 12:54:15

02788 - Internal Communications Error
000 - - - Intermittent
Freeze Frame:
Fault Status: 00100000
Fault Priority: 7
Fault Frequency: 254
Reset counter: 132
Mileage: 34649 km
Time Indication: 0
Date: 2000.00.00
Time: 15:57:21

Freeze Frame:
Bin. Bits: 00000010
Bin. Bits: 00000000

01304 - Radio
008 - Implausible Signal
Freeze Frame:
Fault Status: 01101000
Fault Priority: 5
Fault Frequency: 14
Reset counter: 40
Mileage: 39323 km
Time Indication: 0
Date: 2000.00.00
Time: 18:08:03


-------------------------------------------------------------------------------
Address 15: Airbags Labels: 1K0-909-605.lbl
Part No SW: 1K0 909 605 P HW: 1K0 909 605 P
Component: 5L AIRBAG VW8R 032 7900
Revision: 03032000 Serial number: 0038FD05V1E4
Coding: 0013644
Shop #: WSC 01269 785 00200
VCID: 39730E127042B31

Part No: 1K0 959 339 D
Component: BF-Gewichtsens. 006 0006

1 Fault Found:
00532 - Supply Voltage B+
002 - Lower Limit Exceeded - Intermittent

-------------------------------------------------------------------------------
Address 16: Steering wheel Labels: 1K0-953-549-MY8.lbl
Part No SW: 1K0 953 549 AJ HW: 1K0 953 549 AJ
Component: J0527 034 0070
Coding: 0002022
Shop #: WSC 01279 785 00200
VCID: 7AF1D11E35C4789

Part No: XXXXXXXXXXX
Component: E0221 002 0010

No fault code found.

-------------------------------------------------------------------------------
Address 17: Instruments Labels: 1K0-920-xxx-17.lbl
Part No: 1K6 920 972 E
Component: KOMBIINSTRUMENT VDD 4312
Coding: 0005203
Shop #: WSC 00000 785 00200
VCID: 346D3F2657204E9

No fault code found.

-------------------------------------------------------------------------------
Address 19: CAN Gateway Labels: 1K0-907-530.lbl
Part No SW: 1K0 907 530 F HW: 1K0 907 951
Component: Gateway H10 0120
Revision: H10 Serial number: 2800106424001B
Coding: 7D0F03600F0000
Shop #: WSC 01279 785 00200
VCID: 2A51215E85E4089

1 Fault Found:
01304 - Radio
004 - No Signal/Communication
Freeze Frame:
Fault Status: 01100100
Fault Priority: 2
Fault Frequency: 254
Reset counter: 92
Mileage: 39323 km
Time Indication: 0
Date: 2000.00.00
Time: 17:55:44


-------------------------------------------------------------------------------
Address 1C: Position Sensing Labels: 1Kx-919-xxx-1C.lbl
Part No SW: 1K6 919 879 HW: 1K6 919 879
Component: Kompass 001 0002
Revision: 00001000 Serial number: 1225223T1CV502
Shop #: WSC 00000 000 00000
VCID: FDFB5A02A4EACF1

No fault code found.

-------------------------------------------------------------------------------
Address 25: Immobilizer Labels: 1K0-920-xxx-25.clb
Part No: 1K6 920 972 E
Component: IMMO VDD 4312
Shop #: WSC 00000 000 00000
VCID: 346D3F2657204E9

No fault code found.

-------------------------------------------------------------------------------
Address 42: Door Elect, Driver Labels: 1K0-959-701-MIN2.lbl
Part No: 1K0 959 701 K
Component: Tuer-SG 024 2375
Coding: 0001077
Shop #: WSC 01279 785 00200
VCID: 3669052E415C5C9

1 Fault Found:
00928 - Locking Module for Central Locking; Front Driver Side (F220)
008 - Implausible Signal

-------------------------------------------------------------------------------
Address 44: Steering Assist Labels: 1Kx-909-14x-44.clb
Part No: 1K1 909 144 K
Component: EPS_ZFLS Kl.5 D06 1701
Shop #: WSC 00000 000 00000
VCID: 336F3C3A522E491

No fault code found.

-------------------------------------------------------------------------------
Address 46: Central Conv. Labels: 1K0-959-433-MAX.clb
Part No SW: 1K0 959 433 AS HW: 1K0 959 433 AS
Component: 02 KSG PQ35 G2 010 0101
Revision: 00010000 Serial number: 00000000000000
Coding: 939006885103483F2D04058FB0080A0480A440
Shop #: WSC 00000 785 00200
VCID: 810326F2D812AB1

Component: Sounder n.mounted

Component: NGS n.mounted

Component: IRUE n.mounted

1 Fault Found:
00668 - Supply Voltage Terminal 30
002 - Lower Limit Exceeded
Freeze Frame:
Fault Status: 01110010
Fault Priority: 4
Fault Frequency: 1
Reset counter: 182
Mileage: 76721 km
Time Indication: 0
Date: 2000.00.00
Time: 18:12:21


-------------------------------------------------------------------------------
Address 52: Door Elect, Pass. Labels: 1K0-959-702-MIN2.lbl
Part No: 1K0 959 702 K
Component: Tuer-SG 024 2375
Coding: 0001077
Shop #: WSC 01279 785 00200
VCID: 3777082A4656A51

No fault code found.

-------------------------------------------------------------------------------
Address 55: Xenon Range Labels: 1T0-907-357.lbl
Part No: 1T0 907 357
Component: Dynamische LWR 0003
Coding: 0000003
Shop #: WSC 01279 785 00200
VCID: F4ED7F2697A08E9

No fault code found.

-------------------------------------------------------------------------------
Address 56: Radio
Cannot be reached

End ---------------------------------------------------------------------


Thanks again.

[Anony00GT]

There is a TSB for this. Replace intake flap motor and update software.

[jmjm15213]

Thanks for the reply. Once I replace the motor, where do I obtain the software update from? Does it have a chance of interfering with the ECU flash?

Apologies for the simple questions, still have a lot to learn when it comes to diagnostics / fixes.

[Anony00GT]

Software update either dealer or contact Jack@European Parts on here.

Yes, the software update will eliminate the tune, ECU will have to be re-tuned. Maybe contact APR and see what they have to say about the situation?

[jmjm15213]

Awesome - thank you for the information. I'll get in contact with APR.